Homemade Demi-Glace
Credit: André Baranowski
10 lbs. veal bones
3 carrots, roughly chopped
2 onions, roughly chopped
1 white part of leek, roughly
chopped (optional)
1 Bouquet Garni
1 6-oz. can tomato paste
1. Roast the bones: Browning bones and vegetables in a roasting pan in the oven before combining them in a pot with water gives this stock a more pronounced flavor and deeper color. Veal bones have more collagen than beef bones; simmering the bones transforms the collagen into gelatin, which makes for a thicker, richer stock. Heat oven to 500°. Put bones into a roasting pan large enough to hold them in a single layer and roast until lightly browned, about 1–1 1⁄2 hours. Add carrots, onions, and leeks to the pan and spread them evenly around the bones. At Le Ferrandi and many French restaurants, they leave celery out of their stocks, as they believe it to be too assertive. Roast the bones and vegetables until they are deeply browned, about 45 minutes more.
2. Deglaze the pan: Transfer bones and vegetables to a 15–20-qt. stockpot. Place roasting pan over 2 burners on stove over medium heat. Add 3 cups water to pan; begin scraping up any browned bits from bottom of pan with a wooden spoon. These caramelized morsels of concentrated juice, called the fond—literally, the foundation—will enrich the stock. Simmer for 3 minutes; transfer liquid to pot of bones. Add bouquet garni and tomato paste. The paste will give the stock a deeper flavor and color. Cover bones with 6–8 qts. cold water; set pot over medium-high heat. Starting with cold water encourages the proteins and fats contained in bones to rise to the surface in large pieces, where they can be skimmed and discarded.
3. Simmer the stock: When the first bubbles begin to appear on the surface of the liquid, reduce heat to medium-low and maintain a very gentle simmer; a bubble should rise to the surface about once per second. Simmering slowly prevents the fat and impurities from being churned back into the stock and clouding it. The strength and concentration of your demi-glace will be determined by the length of time the stock simmers. For the minimum amount of extraction, it should simmer for at least 6–8 hours, but we recommend 12–24 hours for a richer, more gelatinous sauce. Check every few hours and add more cold water if necessary so that bones are always covered.
YIELDS 2 CUPS
4. Skim the fat: Skim fatty froth from surface of stock with a ladle every 5–10 minutes during first hour of cooking to prevent it from clouding stock. After first hour, skim the stock every 30 minutes or so.
5. Strain the stock: When the stock is ready, set a chinois (a fine-mesh conical sieve) or a fine metal sieve over a clean 8-qt. pot. Strain stock through sieve into the pot. Tap edge of sieve with a wooden spoon to loosen any solids that impede the straining of the stock, but do not force liquid through. Discard bones, vegetables, and bouquet garni. The bones may be reused to make a lighter, secondary stock with fresh vegetables and aromatics, called remouillage and used for sauces and soups. The stock should yield 4–5 qts. If storing stock for another use, you can cool it quickly by placing the pot in a sink half filled with ice water. Once it's cooled, skim the surface again to remove any fat. Transfer the stock you don't plan to use right away to storage containers and refrigerate. Stock will keep refrigerated for up to 1 week or frozen for up to 6 months. To transform the stock into demi-glace, proceed to next step.
6. Reduce the sauce: Traditionally, the stock for demi-glace was thickened with a roux, but modern chefs have shunned thickeners in favor of reducing stock to a pure, more syrupy consistency. Simmer stock over medium-high heat, skimming occasionally, for 4–5 hours until reduced to 2 cups. Refrigerate for up to 2 weeks or freeze for up to 6 months.
Another option to the recipe is to deglaze the roasting pan with a bottle of red wine instead of plain water.
between the Holidays - it is an all-day process)
and it turned out great! Be careful at the end,
though. I was reducing it from the stock down to
demi-glace and was checking on it every 45
minutes or so. I caught it right before it was
almost all reduced. It almost burned in my pot.
Instead of the medium-high heat suggested in the
recipe. I would recommend just medium heat and
check it often! I almost wasted 26 hours of my
life.
Where am I supposed to find this?
Going to NY for this would not be out of the question since I'm down there a lot, though not generally carting around meat on the train.
-CP